Preview

Izvestiya Vysshikh Uchebnykh Zavedenii. Materialy Elektronnoi Tekhniki = Materials of Electronics Engineering

Advanced search

RESEARCH OPPORTUNITIES FERRITE 2000NM THE SHORT PROCESS FLOW

https://doi.org/10.17073/1609-3577-2013-1-23-27

Abstract

The possibility of obtaining Mn—Zn-ferrite 2000 NM on the short process flow, which differs from the usual lack of diffusion operations roasting and grinding. It is shown that the use of the basic composition in sintering processes develop secondary recrystallization and zonal isolation, leading to the formation of highly inhomogeneous microstructure obtained with low values of the magnetic permeability. A homogeneous microstructure characteristic recrystallization, managed by doping copper oxide and zinc. By doping CuO permeability far from the desired value, but its temperature coefficient is small. By doping ZnO reached the desired value of magnetic permeability, but dramatically increases its temperature coefficient.The optimum combination of the magnetic parameters obtained in complex copper oxides doped ferrite and zinc.

About the Authors

V. G. Kostishin
University of Science and Technology MISiS
Russian Federation


I. I. Kaneva
University of Science and Technology MISiS
Russian Federation


V. G. Andreev
University of Science and Technology MISiS
Russian Federation


A. N. Nikolaev
University of Science and Technology MISiS
Russian Federation


E. I. Volkova
University of Science and Technology MISiS
Russian Federation


References

1. Анциферов, В. Н. Проблемы порошкового материаловедения. Ч. IV. Технология производства порошковых ферритовых материалов / В. Н. Анциферов, Л. М. Летюк, В. Г. Андреев, А. Н. Дубров, А. В. Гончар, В. Г. Костишин, А. И. Сатин. – Екатеринбург: УрО РАН, 2005. – 407 с.

2. Прилипко, Ю. С. Влияние среды спекания на свойства керамики на основе цирконата−титаната свинца и марганец-цинковых ферритов / Ю. С. Прилипко // Порошковая металлургия. – 2009. – №. 12. – С. 70—76.

3. Канева, И. И. Технология материалов магнитоэлектроники. Лабораторный практикум / И. И. Канева, С. В. Подгорная, В. Г. Андреев. – М. : МИСиС, 2012.

4. Ферриты, магнитодиэлектрики. Справочник / Н. Д. Горбунов, Г. А. Матвеев – М. : Советское радио, 1968. – 165 с.

5. Биктяков, Р. М. Стабильность свойств ферритов (Анализ физических свойств при внешних воздействиях, прогнозирование. Элементы проектирования.) / Р. М. Биктяков, Д. В. Гаскаров, Ю. С. Звороно и др. – М. : Советское радио, 1974.

6. Горелик, С. С. Процессы рекристаллизации в ферритах и пути управления ими / С. С. Горелик, И. С. Рыбачук, И. И. Канева // В кн.: Металлы и сплавы в современном приборостроении и радиоэлектронике. – М. : Знание, 1981. – С. 48—51.

7. Горелик, С. С. Рекристаллизация металлов и сплавов / С. С. Горелик, С. В. Добаткин, Л. М. Капуткина. – М. : МИСиС, 2005. – 431с.

8. Синайский, Ю. М. Дисс. канд., 1972.

9. Улановский, Б. М. Дисс. … канд. техн. наук: Исследование, разработка и внедрение ферритовых материалов для элементов БИАКС и технологии их изготовления / Б. М. Улановский. – М. : МИСиС, 1982. – 161 с.

10. Летюк, Л. М. Закономерности формирования микроструктуры ферритов, спекаемых в присутствии жидкой фазы / Л. М. Летюк, Н. Д. Дугар−Жабон и др. // Изв. вузов. Черная металлургия. – 1979. – С. 124—127.

11. Palmer, G. The influence of dopations to the microstructure of Mg—Mn−ferrites / G. Palmer, R. Johnston, R. Schultz // J. Amer. Ceram. Soc. – 1957. – V. 40, N 2. – P. 256—261.


Review

For citations:


Kostishin V.G., Kaneva I.I., Andreev V.G., Nikolaev A.N., Volkova E.I. RESEARCH OPPORTUNITIES FERRITE 2000NM THE SHORT PROCESS FLOW. Izvestiya Vysshikh Uchebnykh Zavedenii. Materialy Elektronnoi Tekhniki = Materials of Electronics Engineering. 2013;(1):23-27. (In Russ.) https://doi.org/10.17073/1609-3577-2013-1-23-27

Views: 968


Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 License.


ISSN 1609-3577 (Print)
ISSN 2413-6387 (Online)